Europe style for Ultrafiltration Water Treatment - UF Membrane Module PVC Ultrafiltration Membrane Module UFc80C Stainless Steel Housing Rain Water Treatment – Bangmo
Europe style for Ultrafiltration Water Treatment - UF Membrane Module PVC Ultrafiltration Membrane Module UFc80C Stainless Steel Housing Rain Water Treatment – Bangmo Detail:
Applications
●Production of mineral water, mountain spring water and other germ-free liquid.
●Drinking treatment of tap water, surface water, well water and river water.
●Pre-treatment of RO device.
●Treatment, recycle and reuse of industrial wastewater.
Filtration Performance
According to the service conditions of modified PVC hollow fiber ultrafiltration membrane which? are? applied to various water? sources, the? product? is? proved to reach below filtration effects:
| Water?Composition | Filtering?Effect |
| Suspended Substances, Particles?>1um | Removal Rate?≥99% |
| SDI | ≤?3 |
| Virus, Bacteria | >4 log |
| Turbidity | <0.1NTU |
| TOC | Removal Rate?0-25% |
Above data is obtained when turbidity of feed water is less than 15NTU. The product is proved to reach the sanitary standards of drinking water by Health Department of Guangdong Province. Approval number is YUE WEI SHUI ZI 2014?S1671.
Product Parameters
Product Appearance
Figure 1 Product Dimensions
Technical Parameters
| Structure | Inside-out |
| Membrane?Material | Modified?PVC |
| MWCO | 100K Dalton |
| Nominal Membrane Area | 16.5m2 |
| Membrane?ID/OD | 1.0mm/1.8mm |
| Module Dimensions | Φ180mm×1382mm |
| Connector?Dimensions | DN25 Female Thread |
Application Data
| Pure?Water?Flux | 7,000L/H?(0.15MPa, 25oC) |
| Designed?Flux | 35-100L/H?(0.15MPa, 25oC) |
| Operating?Pressure | ≤0.2MPa |
| Maximum Trans Membrane?Pressure | 0.2MPa |
| Maximum Operating Temperature | 45oC |
| Operating PH Range | 4-10 |
| Washing PH Range | 2-12 |
| Operating?Mode | Cross-flow/Dead-end Filtration |
Feed Water Requirements
A security filter, precision <50 micron, should be set as pretreatment of UF, in case of? blockage caused by large particles? in? raw water. Attention: UF membrane material is macromolecular organic plastics, raw water must not contain any organic solvents.
| Feed?Water?Turbidity | ≤15NTU |
| Oil & Grease | ≤2mg/L |
| Feed?Water?SS | ≤20mg/L |
| Total?Iron | ≤1mg/L |
| Continuous Feeding Residual?Chlorine | ≤5ppm |
| COD | Suggested?≤500mg/L |
Component Material
| Component | Material |
| Hollow?Fiber?Membrane | Modified?PVC |
| Potting Material | Epoxy?Resins |
| Membrane?Housing | SUS304 |
Typical Operating Parameters
| Maximum Backwashing Pressure | 0.2MPa | |
| Backwashing?Flow?Rate | 100-150L/m2 .h | |
| Backwashing?Frequency | Every?30-60 minutes | |
| Backwashing?Duration | 30-60 seconds | |
| CEB Frequency | 0-4 times/day | |
| CEB Duration | 5-10 minutes | |
| CIP Frequency | 1-3 months | |
| General Washing Chemicals?： | ||
| Disinfection | 15ppm NaClO | |
| Organic?Contamination?Washing | 0.2% NaClo+0.1% NaOH | |
| Inorganic?Contamination?Washing | 1-2% Citric Acid?/0.2% HCl | |
Product detail pictures:
Related Product Guide:
We have been ready to share our knowledge of advertising and marketing worldwide and recommend you suitable products and solutions at competitive price ranges. So Profi Tools supply you benefit of money and we're ready to create with each other with Europe style for Ultrafiltration Water Treatment - UF Membrane Module PVC Ultrafiltration Membrane Module UFc80C Stainless Steel Housing Rain Water Treatment – Bangmo , The product will supply to all over the world, such as: Luxembourg, Hungary, Armenia, In order to meet more market demands and long-term development, a 150, 000-square-meter new factory is under construction, which will be put into use in 2014. Then, we shall own a large capacity of producing. Of course, we are going to continue improving the service system to meet the requirements of customers, bringing health, happiness and beauty to everyone.
By Mavis from Johannesburg - 2018.02.21 12:14
This is the first business after our company establish, products and services are very satisfying, we have a good start, we hope to cooperate continuous in the future!
By Belinda from Paraguay - 2018.02.04 14:13
Write your message here and send it to us
Products categories
-
Online Exporter Membrane Bioreactor System - M...
-
Factory wholesale Mbr Wastewater Treatment Proc...
-
Free sample for Water Cartridge - MBR Membrane...
-
18 Years Factory Waste Water Filter System - M...
-
Discount Price Hollow Fiber Uf Membrane - UF M...
-
2022 China New Design Water Purifiers Filters -...